CAT 627G Especificações Página 15
- Página / 77
- Índice
- MARCADORES
Avaliado. / 5. Com base em avaliações de clientes
SEBU7858-03 111
Maintenance Section
Bowl Lift Cylinder Bearings - Lubricate
Replace
If the belts need replacement, refer to the Service
Manual or cont
act your local Caterpillar dealer.
i02556173
Bowl Lift Cylinder Bearings -
Lubricate
SMCS Code: 5303-086-BD
S/N: DBZ1-Up
g01128849
Illustration 121
The fittings for the bowl lift cylinder bearings are
locatedonthefrontofthebowl.
1. Wipe the fittings before you apply lubricant
through the fittings.
2. Apply the appropriate lubricant through each fitting
in order to lubricate the bowl lift cylinder bearings.
i02443636
Brake Air System Pressure -
Test
SMCS Code: 4250-081-PX
g01220965
Illustration 122
1. Start the engine and look at air pressure gauge
(2). Allow the brake system air pressure to reach
850±50kPa(125±10psi).
2. Apply the service brake by holding down service
brake pedal (1).
3. Stop the engine.
4. The reading on the air pressure gauge should not
drop by more than 35 kPa (5 psi) after the engine
is stopped for 10 minutes. Repair the brakes, if
necessary.
i01401548
Brake Ai r System Warning
Horn - Test
SMCS Code: 7402-081; 7408-081
The warning horn for the air brake system should
sound when the air pressure gauge shows a reading
below 517 ± 35 kPa (75 ± 5 psi).
1. The parking brake should be in the ENGAGED
position.
2. The transmission control should be in the
NEUTRAL position.
- MAINTENANCE INTERVALS 1
- Operation and 2
- Maintenance 2
- Maintenance Interval Schedule 3
- Air Dryer - C he ck 5
- Air Dryer Desiccant - Replace 6
- Air Tank Moisture and 6
- Sediment-Dra 6
- Auger Be 7
- Auge r Bearing Oil Level 8
- Illustration 111 9
- Illustration 112 9
- Auger Drive G ear Oil Level 10
- Auger Hydraulic System Oil 10
- Filter - Rep la 10
- Auger Seal - Insp ect/Replace 11
- Auger Shoes a 12
- Edges - Inspect/Replace 12
- Backup Alarm - Test 12
- Illustration 118 13
- Belts - Inspect/Replace 14
- Illustration 121 15
- Illustration 122 15
- Brake Ca msh aft Bearing 16
- Lubricate 16
- Brake Shoes and Drum s 16
- Inspect/Replace 16
- Braking System - Test 17
- Outside Filters 18
- Circuit Breakers - Rese t 19
- Condenser (Refrigerant) 20
- - Change 21
- Procedure for the Scraper 22
- Coo ling System Coolant 23
- Extender (ELC) - Add 23
- - C heck 23
- Cooling System Coolan t 24
- Sample (L evel 24
- 1)-Obtain 24
- Sample (L evel 2) - Ob tain 25
- Illustration 140 26
- Pressure cap for the tractor 26
- Pressure cap for the scraper 26
- Crankshaft Vibration Dampe r 27
- -Inspect 27
- Cutting Edges and End Bits 28
- Inspect/Repl 28
- Illustration 144 29
- Illustration 145 29
- Illustration 146 29
- Procedure for the Tractor 30
- Level - Ch eck 32
- Sample 32
- Illustration 158 33
- Illustration 159 33
- Ejector Carrier Rollers 34
- Inspect/Pack/Replace 34
- Ejector Guide Ro llers 34
- Check/Adjust 34
- Ejecto r Guide Ro llers 35
- Ejector Support Rollers 35
- Illustration 164 36
- Cleaning Primary Air Filter 37
- Elements 37
- Engine Air Filter Secondary 39
- Element - Replace 39
- Engine Air Filter S ervice 39
- Indicator - Inspect 39
- Engine Air Filter Service 40
- Indic ator - Inspect/Replace 40
- Engine Air Precleaner - Clean 40
- Engine Oil (High Speed) and 41
- Oil Filter - Ch 41
- Illustration 176 42
- Illustration 177 42
- Engine Oil Level - Check 43
- Engine O il Sam ple - O btain 44
- (Trac tor En gin e ) 44
- Illustration 184 45
- Illustration 185 45
- (Scraper Engine) 46
- Engine Valve La sh - Check 47
- Evaporator Coil and Heater 48
- Coil - Clean 48
- Fuel Sy stem - Prime 49
- Fuel System Primary Filter 50
- (Water Separator) Element 50
- Fuel System Water Separato r 53
- Illustration 201 54
- Typical exam p le 54
- Illustration 202 54
- Fuses - Replace 55
- Hitch - Inspect 56
- Hitch - Lubr 57
- Hydraulic Oil Cooler - Clean 57
- Illustration 210 58
- Illustration 211 58
- Hydrau lic System Oil Fil ter 59
- (Pilot) - Repl ace 59
- Hydraulic System Oil Filter 60
- Hydraulic System Oil Level 61
- Hydraulic System O il Sam ple 61
- Valve - Clean 62
- Oil Filter - Inspe ct 63
- Push Plate - Lubricate 63
- Radiator Co re - Clean 63
- Refrig erant Dryer - Replac e 64
- - Inspect 64
- Seat Belt - Inspect 65
- Seat Belt - Replace 65
- Secondary Steering - Test 65
- (If Eq uipped) 65
- Steering Pum p Outlet Screen 66
- Suction Screen (Transm ission 66
- Scavenge) - C le an 66
- Procedure for 67
- Tire Inflation - Check 68
- Tran smiss ion Breathers 68
- Transmission Oil - Chang e 69
- Transmissio n Oil Filter 71
- Replac e/Clean 71
- Magnetic Screen 72
- Transmission Oil Sample 75
- Wheel Coolant Level - C hec k 75
- Illustration 243 76
- Illustration 244 76
- Illustration 245 77
© 2020, manymanuals-pt.com. Todos os direitos reservados. | 0.035 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comentários a estes Manuais